RELIANCE 57C493

描述

RELIANCE 57C493

第一类故障点(也是故障最多的地点)在继电器、接触器。如该生产线PLC控制系统的日常维护中，电气备件消耗量最大的为各类继电器或空气开关。主要原因除产品本身外，就是现场环境比较恶劣，接触器触点易打火或氧化，然后发热变形直至不能使用。在该生产线上所有现场的控制箱都是选用密闭性较好的盘柜，其内部元器件较其他采用敞开式盘柜内元器件的使用寿命明显要长。所以减少此类故障应尽量选用高性能继电器，改善元器件使用环境，减少更换的频率，以减少其对系统运行的影响。

第二类故障多发点在阀门或闸板这一类的设备上，因为这类设备的关键执行部位，相对的位移一般较大，或者要经过电气转换等几个步骤才能完成阀门或闸板的位置转换，或者利用电动执行机构推拉阀门或闸板的位置转换，机械、电气、液压等各环节稍有不到位就会产生误差或故障。长期使用缺乏维护，机械、电气失灵是故障产生的主要原因，因此在系统运行时要加强对此类设备的巡检，发现问题及时处理。我厂对此类设备建立了严格的点检制度，经常检查阀门是否变形，执行机构是否灵活可用，控制器是否有效等，很好地保证了整个控制系统的有效性。

第三类故障点可能发生在开关、极限位置、安全保护和现场操作上的一些元件或设备上，其原因可能是因为长期磨损，也可能是长期不用而锈蚀老化。如该生产线窑尾料球储库上的布料行走车来回移动频繁，而且现场粉尘较大，所以接近开关触点出现变形、氧化、粉尘堵塞等从而导致触点接触不好或机构动作不灵敏。对于这类设备故障的处理主要体现在定期维护，使设备时刻处于完好状态。对于限位开关尤其是重型设备上的限位开关除了定期检修外，还要在设计的过程中加入多重的保护措施。

第四类故障点可能发生在PLC系统中的子设备，如接线盒、线端子、螺栓螺母等处。这类故障产生的原因除了设备本身的制作工艺原因外还和安装工艺有关，如有人认为电线和螺钉连接是压的越紧越好，但在二次维修时很容易导致拆卸困难，大力拆卸时容易造成连接件及其附近部件的损害。长期的打火、锈蚀等也是造成故障的原因。根据工程经验，这类故障一般是很难发现和维修的。所以在设备的安装和维修中一定要按照安装要求的安装工艺进行，不留设备隐患。

第五类故障点是传感器和仪表，这类故障在控制系统中一般反映在信号的不正常。这类设备安装时信号线的屏蔽层应单端可靠接地，并尽量与动力电缆分开敷设，特别是高干扰的变频器输出电缆，而且要在PIC内部进行软件滤波。这类故障的发现及处理也和日常点巡检有关，发现问题应及时处理。

第六类故障主要是电源、地线和信号线的噪声(干扰)，问题的解决或改善主要在于工程设计时的经验和日常维护中的观察分析。

要减小故障率，很重要的一点是要重视工厂工艺和安全操作规程在日常的工作中遵守工艺和安全操作规程，严格执行—些相关的规定，如保持集中控制室的环境等等，同时在生产中也要加强这些方面的霄理。

产品承诺：
保 证 全新原装进口,
保 证 安全准时发货，
保 证售后服务质量，
优势价格，大量现货。

主营DCS系统配件
机器人系统配件
大型伺服系统配件
品牌：ABB   ,AB  ,GE,FOXBORO,本特利，英维思，伍德沃德，西屋，瑞恩，施耐德，西门子，摩托罗拉，安川。力士乐。ACSO，横河等进口品牌。Triconex Siemens Yaskawa ABB GE Ovation AB Foxboro Motorola Schneider XYCOM KUKA

Parker Pressure Comp Flow Control 3000PSI # PCMS1600S

Parker Pressure Comp.Hydraulic Flow Control 3000PSI PCM

Parker Hydraulic Pump Pressure Comp Piston 32GPM P2075P

PARKER HYDRAULIC PRESSURE REDUCING VALVE~NEW~SURPL​US~

PARKER 422-8-RL MEDIUM PRESSURE HYDRAULIC HOSE 1/2″

PARKER PR3MM Pressure Reducing Valve

NEW PARKER R6PH PRESSURE CONTROL VALVE

3 Parker Low Pressure Regulators SQMICRO130E602P​FSMM

Parker Hydraulic Pressure/Temp CompFlow Control FG3PKCA

PRESSURE REDUCING GAUGE VERIFLO PARKER NPR73530W4PXFSM

Parker Proportional Pressure Valve NIB

New Overstock Parker A4ADB Pressure Regulator Valve

Parker Low Pressure Regulator SQ2MICRO0302PFS​MM New

NEW PARKER PRESSURE SWITCH SCPSD-250-04-17
With 90 warranty

Parker 240′ 1/2″ Low Pressure 250 PSI Rubber Hose 801-8

PARKER PRESSURE REGULATOR VALVE – REFRIGERATION

Parker RAS-600-S4 RAS600S4 RAS600S Pressure Valve NEW
One-day shipping available

Parker Hydraulic Pressure Compensated Flow Control

Parker RAS600S Pressure Control Valve RAS600S
One-day shipping available

Parker Flo Con SportII37 Refrigerant Pressure Regulator

Parker Flo Con SportII79 Refrigerant Pressure Regulator

Parker Flo ConSportII911 Refrigerant Pressure Regulator

Parker PRC3MM Pressure Control Valve Hydraulic
Expedited shipping available

8523 NEW Parker A4AD Pressure Regulator

Parker 214′ 1/2″ Low Pressure 250 PSI Rubber Hose 801-8

2658 NEW PARKER A4AD Refrigerant Pressure Regulator

Parker PR-1-4114-2 High Purity Pressure Regulator
One-day shipping available

PARKER PSB040AF1A HYDRAULIC PRESSURE SWITCH NIB

Parker PR-3-4118-1 ½” PTFE Pressure Regulator

Parker 959100W2PFSMM High Pressure Regulator NEW
One-day shipping available

PARKER PRESSURE DRIVER CARD 801179 **NICE**

PARKER PRM3AA25KNS 50 PRESSURE CONTROL VALVE New

Parker Hydraulic Pump Pressure Comp Piston 5GPM #PAV10

Parker BC10BMV 10 pressure control Valve NNB BC10BMV10

PARKER PRDM3PP02SVS PRESSURE REDUCING VALVE 315 BAR NEW

Parker Hydraulic Pump Pressure Comp Vane 45D10L1A1B1AC

Parker Veriflo Pressure Regulator
One-day shipping available

Parker 3000 PSI Hyd Pressure Cylinder 03.25JJ2HTS #6078

Parker Oildyne OE4-SBHS-5K Hydraulic Pressure Switch

Parker Convum MPS-R3F5-NC Stainless Pressure Sensor New
Expedited shipping available

PARKER A810E FLO-CON OUTLET PRESSURE REGULATOR 85272

New Parker Manapak Pressure Reducing Valve PRM3PA17KN32
One-day shipping available

PARKER REGULATOR BACK PRESSURE, BR-3-1168-2

Parker Low Pressure Regulator SQMICRO130E602P​FSMM New

Parker Low Pressure Regulator SMSQ2MICRO30102 New

Parker Hyd Pressure Reducing Valve PRDM2PP16SUS (NIB)

NEW PARKER VERIFLO DSG HP PRESSURE REDUCING REGULATOR

NEW, PARKER PRESSURE REDUCING VALVE PR800SM-20KE

Parker RAS-600-S4 RAS600S4 RAS600S Pressure Valve USED
One-day shipping available

Parker hydraulic pressure reducing valve FM3DDKN-50

Parker Hydraulic Pressure Reducing Valve

Parker Hydraulic Ring ASB250AF1A4 Pressure transducer

Parker Schrader Bellows Pressure Regulator 3568-2000

7134 NEW Parker A4A Pressure Regulator 1″

Parker Pressure Reducing Valve AR FM3DDKN 55

Parker Pressure Reducing Valve DR FM3DDKN 55

Parker 621B-6 Pressure Control Valve 621B6 USED
One-day shipping available

Parker PRDM2PP16SVG, Pressure Reducing Valve NEW

Parker PRDM2BB16LVM, Pressure Reducing Valve NEW

Parker PRDM2BB02LNM, Pressure Reducing Valve NEW

Parker PRDM2PP02LNM, Pressure Reducing Valve NEW

PARKER 626092 OILDYNE PRESSURE SWITCH 0E4-SBKS-44K NEW
Expedited shipping available

PARKER HYDRAULIC PRESSURE REDUCING VALVE PRDM2PP16LNS
Expedited shipping available

PARKER PRDM2PP16SVGX79​7 PRESSURE REDUCING VALVE NIB

PARKER HYDRAULIC PRESSURE REDUCING VALVE R6PM

PARKER MODEL A4A PRESSURE REGULATOR 2 1/2″ NEW

PARKER PRM3PP25K HYDRAULIC PRESSURE CONTROL VALVE

Parker Flo-Con By-Pass Pressure Regulator SM080128 NIB

Parker 41975 20-20 Clamp SAE flange high pressure

Parker Pressure Filter F3-15P-1-40SA-E​S-50-XX-11-80

Parker PRM3PAH-20GB Pressure Reducing Valve

Parker PR400SHV Pressure Reducing Valve

NOS! PARKER REMOTE PRESSURE AIR VALVE CWJ12501

NEW Parker Hydraulic Filter 932630Q High Pressure

Parker D39DW11C4N89 75, PRESSURE REGULATION VALVE , NEW

PARKER VERIFLO IR400S4PG PRESSURE REDUCING REGULATOR

NOS! PARKER REMOTE PRESSURE VALVE CC1225B

LOT PARKER VERIFLO PRESSURE TRANSDUCER SWITCH DWYER

Parker Oil Pressure Regulator Control Valve A4AL; *A7

Parker high pressure clamp flange elbow 41775-16-16

Parker 41575 16-16 Clamp SAE flange high pressure 1 in

Parker Pressure Regulator P3NRA1PBPP

Parker 035682000B Pressure Regulator

Parker Veriflo 944AOPLPNOSFSFF High Purity Low Pressure

PARKER HIGH PRESSURE BALL VALVE # BV3H06S2SS1N

PARKER 035662000B PRESSURE REGULATOR 5-125 PSIG NEW

Pressure Pump Inlet Filter **NEW** Part#1J2-5

Parker Flo-Con Pressure Regulator A7-A

PARKER H2 1/2″ SAFETY PRESSURE RELIEF VALVE REFRIGERANT

Parker 73212BN52N00 3/4″ Skinner Pressure Vessel 2-Way

Parker Scrader Bellows Pressure Regulator 035662000B

PARKER FP2AUS14 250 PRESSURE 1.000 STROKES AIR

Parker Veriflo IR4205 Stainless High Pressure Regulator

Parker Veriflo 1/4″ Pressure Regulator (SQ2MICRO130E60​)

PARKER REMOTE PRESSURE VALVE CC1225B 150 PSI DO 1/4″

Parker Pressure Regulator 72-130
Expedited shipping available

PARKER Flo-Con Pressure Regulator A8-AOE

5 PARKER SENSOCONTROL PRESSURE SWITCH SCPSD-600-04-07

3 NEW PARKER MANAPAK PRESSURE CONTROL VALVES PRM2PP07KN

LOT 2 PARKER PRESSURE REGULATOR MASTER PNEUMATIC FILTER

parker bvhp12bss1na HIGH PRESSURE BALL VALVE

Parker PRM3 PP17K Pressure Reducing Valve 150-2500 PSI

NEW PARKER FLO-CON BYPASS HOT GAS PRESSURE REGULATOR A9

PARKER/SCHRADER BELLOWS PRESSURE REGULATOR 035662000B

PARKER FLO-CON A7 PRESSURE REGULATOR 400 PSI
One-day shipping available

A810E Parker FLOCON 1-3/8″ Outlet Pressure Regulator
One-day shipping available

2683 NEW Parker 201673 Pressure Regulator

PARKER HYDRAULIC PRESSURE REDUCING VALVE V-21 FT

New Parker CPOM2AAV55X Pilot-Oper. Pressure Check Valve
Expedited shipping available

NIB PARKER BVHP16SSS1NA HIGH PRESSURE BALL VALVE
Expedited shipping available

Parker 035643000B Pressure Regulator NEW Free Shipping
One-day shipping available

Parker Hydr. Pressure Reducing Module D03 # BD03PNR-A

PARKER 1/4 NPT CONTROLLED PRESSURE SAFETY THUMB LEVER

Parker hydraulic cylinder model C2H19 PRESSURE 3000

New Parker 06E21A18AC Filter Regulator w/Pressure Gauge

Parker 3/8″ S. Air Dual Pressure Switch New

Parker Hannifin Hydraulic Pressure Control Valve 3000

Parker Pressure Switch Male DIN P01909

PRESSURE REDUCING RELIEF VALVE, PARKER #PR101S10-C3F

Parker SensoControl Senso Control SCP-8181 Pressure

NEW PARKER BI-PRESSURE PUMP CONTROL FPS-213

PARKER PRESSURE REDUCING HYDRAULIC VALVE PRM3PB25KN 32

PARKER PRESSURE REDUCING HYDRAULIC VALVE PRM3PAH-20HY

NEW PARKER VERIFLO IR501B6P0140458​0 PRESSURE REGULATOR

Parker grade 10 Hi pressure filter element 10CWC08-033

*NEW* Parker Senso Control Pressure Controller #SCPSD

Parker 1/2″ remote pressure valve SS121050 NIB
One-day shipping available

PARKER VERIFLO 43200648 PRESSURE TRANSDUCER

MAZAK PARKER PRESSURE REGULATOR UNIT

Parker Veriflo Pressure Regulator Valve 742793

Ewal/Parker Titan II 1/4″ Pressure Actuation Valve

Parker Veriflo Pressure Regulator Valve 45100064 SS

New Parker Veriflo Pressure Regulator 43800745 Series

Parker 71216SN2FU00 Skinner Valve Pressure Vessel

PARKER PRM2PP07LN 42 HYDRAULIC PRESSURE CONTROL VALVE

Parker MPS Convum PRESSURE Switch P6N-PG(11)

Parker sandvik high pressure hydraulic filter housing

2669 NEW Parker A4AZ Inlet Pressure Regulator

PARKER REFRIDGERANT INLET PRESSURE REGULATOR A8 A81

Parker pressure regulator 8311

PARKER PRESSURE REGULATOR

PARKER HYDRAULIC PRESSURE REDUCING VALVE ~NEW~SURPLUS~

Parker 035632000B Pressure Regulator

2 NIP NEW PARKER PRESSURE SWITCH PS1-P1091 81099

PARKER 9S HI PRESSURE SWIVEL PS1690106-16-16

PARKER 035642000B PRESSURE REGULATOR 5-125 PSIG NEW

NEW PARKER BVHP08SSS1NA HIGH PRESSURE BALL VALVE
Expedited shipping available

OILDYNE PRESSURE SWITCH PARKER 626092 NEW

PARKER PRESSURE REGULATOR 035631000B

PARKER PRESSURE REGULATOR 035642000B

Parker Veriflo SS Pressure Regulator 1/4″ 4-Port HIR103

Parker 06E21A18AC Filter Regulator Pressure Gauge

PARKER UHP VALVE…VALVE PRESSURE 150 PSI MAX.

Ewal/Parker 1/4″ Inline Needle Pressure Air/Gas Valve

PARKER 07R313AC 1/2″ 250PSI AIR PRESSURE REGULATOR

PARKER HYDRAULIC PRESSURE REDUCING VALVE ~NEW~SURPLUS~

3957 NEW Parker PR101S20 Hyd Pressure Reducer Valve

7 NEW PARKER VERIFLO PRESSURE RELIEF VALVE 110ST100

PARKER HI PRESSURE LIVE SWIVEL

Veriflo PARKER Gas / Pressure Valve Diaphragm

PARKER PRESSURE REGULATOR 5-125 PSIG

PARKER HHR1 SANDWICH PRESSURE REGULATOR W/GAUGE NEW

PARKER SCHRADER 0-60 PSIG 035600200 PRESSURE GAUGE NIB

Parker Hydraulic Pressure Filter 5W353 925580

PARKER HANNIFIN PARFLEX HIGH PRESSURE HOSE ASEMBLY

PARKER PNEUMATIC – PRESSURE REGULATOR 06R213AB 250PSI
Expedited shipping available